Trailer Mounted Reclaimers

RC4000

The Ray-Tech RC4000 is the smallest of our line of trailer mounted reclaimers.

 

 

 

The RC4000 features a 2 ton capacity reclaimer mounted on a dual axle trailer. There are two shovel doors on the rear of the unit. This unit comes in either a propane (RC4000) or diesel (RC4000D) fired configuration.

This unit is capable of holding hot mix asphalt at a workable temperature for 48 hours without damage to the material. It is also capable of reclaiming cold asphalt to a working temperature in 12 hours.

 

 

 

  • Plate Compactor Platform – 24″ x 24″ platform with a manual winch mounted on a swivel boom.
  • Roller Cradle – Steel cradle with a heavy duty electric winch mounted on a swivel boom.
  • Time Delay System (TDS) – Preset the time for the reclaimer to turn on.
  • Cold Patch Heating Controls – Additional thermostat controls to heat cold patch material. (Not available on diesel)
  • Hydraulic Dump – Configured to dump to the rear of the unit with single piston and pump.
  • 21 Gallon Heated Tack Tank – 21 gallon tank with independently controlled burner and gravity discharge.
  • 12V LED Work Light – 12V LED work light mounted above discharge doors.
  • LED Arrow Stik Light Bar – Light bar with control module showing flash pattern being used.
  • Hydraulic Brakes – Surge hydraulic brakes instead of standard electric brakes.
  • Spare Tire & Wheel – Spare tire mounted on rim and attached to side of reclaimer box.

 

 

 

  • Fully automatic ignition with the flip of a switch.
  • Timers and thermostats for reclaiming and holding operation.
  • Heavy duty boxed channel frame.
  • Two 6,000 lb axles with electric brakes on each wheel.
  • Two manually operated discharge doors at rear of unit.
  • Two manually operated loading doors that form a chute.
  • 12 gallon rinse tank to clean tools.
  • LED lighting throughout.
  • 12 volt battery with charger system for easy charging overnight.
  • Sloped hopper walls to steer asphalt down and out to the discharge doors.

Propane:

  • Two 35,000 BTU burners located under hopper.
  • Two 100 LB propane cylinders with lockable cover.

Diesel:

  • One Beckett 12V burner.
  • 20 gallon fuel tank with inline filter.
  • One additional 12V battery wired inline with first battery for added run time.

 

 

  • Length: 11′ 8″
  • Width: 7′ 2″
  • Height: 6′ 4″
  • Empty Weight: 4,300 lbs
  • Gross Weight: 9,500 lbs

 

RC6000

The Ray-Tech RC6000 is the newest addition to our line of Reclaimer units. It is a trailer mounted unit that can reclaim used asphalt to a workable temperature and consistency within 16 hours.

 

 

 

The RC6000 features a 3 ton capacity reclaimer mounted on a dual axle trailer. There are three shovel doors on the rear of the unit. This unit comes in either a propane (RC6000) or diesel (RC6000D) fired configuration.

This unit is capable of holding hot mix asphalt at a workable temperature for 48 hours without damage to the material. It is also capable of reclaiming cold asphalt to a working temperature in 12 hours.

 

 

 

  • Plate Compactor Platform – 24″ x 24″ platform with a manual winch mounted on a swivel boom.
  • Roller Cradle – Steel cradle with a heavy duty electric winch mounted on a swivel boom.
  • Time Delay System (TDS) – Preset the time for the reclaimer to turn on.
  • Cold Patch Heating Controls – Additional thermostat controls to heat cold patch material. (Not available on diesel)
  • Hydraulic Dump – Configured to dump to the rear of the unit with single piston and pump.
  • 21 Gallon Heated Tack Tank – 21 gallon tank with independently controlled burner and gravity discharge.
  • 12V LED Work Light – 12V LED work light mounted above discharge doors.
  • LED Arrow Stik Light Bar – Light bar with control module showing flash pattern being used.
  • Hydraulic Brakes – Surge hydraulic brakes instead of standard electric brakes.
  • Spare Tire & Wheel – Spare tire mounted on rim and attached to side of reclaimer box.

 

 

 

  • Fully automatic ignition with the flip of a switch.
  • Timers and thermostats for reclaiming and holding operation.
  • Heavy duty boxed channel frame.
  • Two 6,000 lb axles with electric brakes on each wheel.
  • Three manually operated discharge doors at rear of unit.
  • Two manually operated loading doors that form a chute.
  • 12 gallon rinse tank to clean tools.
  • LED lighting throughout.
  • 12 volt battery with charger system for easy charging overnight.
  • Sloped hopper walls to steer asphalt down and out to the discharge doors.
  • Mounting brackets on rear of unit to accommodate a Ray-Tech Mini Tech or Mini Tech Xtend.

Propane:

  • Two 37,000 BTU burners located under hopper.
  • Two 100 LB propane cylinders with lockable cover.

Diesel:

  • One Beckett 12V burner.
  • 20 gallon fuel tank with inline filter.
  • One additional 12V battery wired inline with first battery for added run time.

 

 

  • Length: 14′ 2″
  • Width: 8′ 0″
  • Height: 8′ 8″
  • Empty Weight: 4,600 lbs
  • Gross Weight: 10,800 lbs

 

RC8000

The Ray-Tech RC8000 is the largest trailer mounted unit of our line of Asphalt Reclaimers. It was engineered to reclaim a full load of used asphalt to a workable temperature and consistency within 16 hours.

 

 

 

The RC8000 features a 4 ton capacity reclaimer mounted on a dual axle trailer. There are three shovel doors on the rear of the unit. This unit comes in either a propane (RC8000) or diesel (RC8000D) fired configuration.

This unit is capable of holding hot mix asphalt at a workable temperature for 48 hours without damage to the material. It is also capable of reclaiming cold asphalt to a working temperature in 12 hours.

 

 

 

  • Plate Compactor Platform – 24″ x 24″ platform with a manual winch mounted on a swivel boom.
  • Roller Cradle – Steel cradle with a heavy duty electric winch mounted on a swivel boom.
  • Time Delay System (TDS) – Preset the time for the reclaimer to turn on.
  • Cold Patch Heating Controls – Additional thermostat controls to heat cold patch material. (Not available on diesel)
  • Hydraulic Dump – Configured to dump to the rear of the unit with single piston and pump.
  • 21 Gallon Heated Tack Tank – 21 gallon tank with independently controlled burner and gravity discharge.
  • 12V LED Work Light – 12V LED work light mounted above discharge doors.
  • LED Arrow Stik Light Bar – Light bar with control module showing flash pattern being used.
  • Hydraulic Brakes – Surge hydraulic brakes instead of standard electric brakes.
  • Spare Tire & Wheel – Spare tire mounted on rim and attached to side of reclaimer box.

 

 

 

  • Fully automatic ignition with the flip of a switch.
  • Timers and thermostats for reclaiming and holding operation.
  • Heavy duty boxed channel frame.
  • Two 7,000 lb axles with electric brakes on each wheel.
  • Three manually operated discharge doors at rear of unit.
  • Two manually operated loading doors that form a chute.
  • 12 gallon rinse tank to clean tools.
  • LED lighting throughout.
  • 12 volt battery with charger system for easy charging overnight.
  • Sloped hopper walls to steer asphalt down and out to the discharge doors.

Propane:

  • Two 35,000 BTU burners located under hopper.
  • Two 100 LB propane cylinders with lockable cover.

Diesel:

  • One Beckett 12V burner.
  • 20 gallon fuel tank with inline filter.
  • One additional 12V battery wired inline with first battery for added run time.

 

 

  • Length: 14′ 2″
  • Width: 8′ 0″
  • Height: 8′ 8″
  • Empty Weight: 4,800 lbs
  • Gross Weight: 14,000 lbs